• 🔖 It looks like you are browsing the site as a guest. By registering on the site you can participate on the Internet's largest Polaris Ranger XD 1500 forum. To register, simply Click Here!

Xd 1500 transmission

J

Jcw

New member
Feb 17, 2024
4
3
Good day, took my xd1500 in to dealer after two months and 160 miles with a noise coming from where I thought was the windshield hold down area. Sounds like loose nuts and bolts rattling around. Dealer test drive and noticed another noise coming from the rear transmission area, removed skid plate and rocker panels, Polaris HQ engineers said to check fluid level and would advise from there. Anyone else having transmission noise?
 
Jcw said:
Good day, took my xd1500 in to dealer after two months and 160 miles with a noise coming from where I thought was the windshield hold down area. Sounds like loose nuts and bolts rattling around. Dealer test drive and noticed another noise coming from the rear transmission area, removed skid plate and rocker panels, Polaris HQ engineers said to check fluid level and would advise from there. Anyone else having transmission noise?
Click to expand...
Nothing on this end. Over 500 miles. Keep us updated.
 
Check where the bed lift cylinder mounts to the bed it will slide side to side and make noise when not under load. One garden hose rubber washer on each side of the cylinder on the inside of the bracket works perfect.
 
Last edited:
1700 miles and bad whine coming from trans,, sounds like a power steering pump that is bad.. took to dealer and was told they were putting in whole new transmission,, under warranty
 
Steven3 said:
1700 miles and bad whine coming from trans,, sounds like a power steering pump that is bad.. took to dealer and was told they were putting in whole new transmission,, under warranty
Click to expand...
Sorry you’re out with your XD. I’m glad to hear they are replacing under warranty as they should. Please keep us updated.
 
Jcw said:
Good day, took my xd1500 in to dealer after two months and 160 miles with a noise coming from where I thought was the windshield hold down area. Sounds like loose nuts and bolts rattling around. Dealer test drive and noticed another noise coming from the rear transmission area, removed skid plate and rocker panels, Polaris HQ engineers said to check fluid level and would advise from there. Anyone else having transmission noise?
Click to expand...
We had one go completely out with less than 100 miles on it. Polaris replaced it no problem.
 
You must log in or register to reply here.
Back
Top